2012 rzr 800s front diff issues

My 2012 rzr 800s is stuck engaged in awd in the forward gears and no awd in reverse. I have tested and I have just under the 11 volts required at the plug. Also checked the ohms in the front diff and if my meter is reading right it’s showing 35 ohms, which is...

12 800 S secondary locked up

Hi all looking for some help. I recently purchased a 2012 rzr 800S. We rode it for 200ish miles and then coming down a mountain road in low at an idle the rear end locked up and now the shifter goes in low neutral reverse and park not into high. The secondary will not...
RZR s Clutch pulling and other Mess

RZR s Clutch pulling and other Mess

Hello Everyone, I’m new. I have a 2013 RZR S that I got in a trade for a jeep. I’ve taken it out a couple times, and have gotten the belt wet (pretty easily) and decided to pull the cover, clean it up, and snorkel it. This is what I ran into: The whole...

800 Waterseal Weephole Help!!!!!!!!

Had a buddy replace water pump seal because antifreeze leaking out of weep hole year-and-a-half ago, since then haven’t put but 10 or 15 hours on machine an coolant still would leak from the weep hole. So I just changed water pump seal and water pump cover...

Grinding noise at High and Low

Hello all. My first issue with the rzr and I’m not too knowledgeable hope I can get some help here. I was riding today and I noticed everytime I came to a stop in High gear, the engine would stall and shut off. Happened several times. The High gear would be stuck and...
Page 1 of 1812345...10...Last »